Flake and nugget ice machine repair on auger-driven units used for seafood displays, bars, spas and medical rooms, where a seized auger or worn gearbox stops output. In Hurlingham this is sandton prime work on auger-driven flake and nugget ice systems, attended within about 50 minutes of dispatch.We work across every major brand installed in Hurlingham, and diagnostics start from the plated design data rather than a guess.Codes are read from the board rather than guessed at, then traced to the actual sensor, valve or drive fault behind them.Manor and estate sections require pre-booked access. Ice Machine Repairs bookings in Hurlingham are logged against Block 6 so we can allow for power availability on site.
- Typical response window
- 50 minutes from Sandton
- Distance from Sandton CBD
- 4.8 km
- Municipal water hardness
- moderate (140 ppm)
- Load-shedding schedule
- Block 6
- Access & compliance
- Manor and estate sections require pre-booked access.
- Typical installed systems
- Large stands, cellar cooling and pool heat pumps.
Refrigerant data
| Gas | Classification | Suction pressure | Discharge pressure | Typical use |
|---|---|---|---|---|
| R404A | HFC blend (near-azeotropic) | 40-60 kPa (approx. 2-4 bar) | 1500-1900 kPa | Older commercial ice machines, cube makers, ice bins and blast chillers |
| R448A | HFO/HFC blend (low GWP) | 50-75 kPa | 1600-2000 kPa | Modern commercial ice machines, cube and flake units, coldroom retrofits |
| R290 (propane) | Natural hydrocarbon (A3 flammable) | 30-50 kPa | 1000-1400 kPa | Undercounter and self-contained ice makers, nugget machines, back-bar units |
Common questions
How long does a flake ice machine auger last?
On hard Johannesburg water an auger and gearbox typically run five to eight years. We check gearbox oil condition, bearing play and motor current at every service, because a worn water seal leaking into the gearbox is what usually kills the drive.
Do you charge a callout fee?
A standard callout and diagnostic fee applies and is quoted upfront. It is credited against the repair when you accept the quote.
Is a compressor replacement guaranteed?
Yes. Replacements are done with a system flush and new drier, and both part and workmanship are warranted, provided the original cause of failure is corrected.
My ice machine runs but makes no ice, is it worth repairing?
Usually yes. The four common causes (water inlet valve, water pump, scaled evaporator and a stalled harvest cycle) are all repairable at a fraction of replacement cost. We quote in writing after the diagnostic and tell you honestly when a machine is past economic repair.
Request a callout or quote
Send it straight to our WhatsApp for the fastest response, or call 069 268 0988 / email info@reyds.co.za.